economie

Boeing’s terrible, horrible, no good, very bad year

October 13, 20240
The fuselage plug section of Alaska Airlines Flight 1282.

NTSB via Reuters

The problems began almost immediately this year when, on January 5, Alaska Airlines Flight 1282 lost a door plug midair, blowing a hole in the side of the plane. While no one died in the incident, several passengers were injured, and the pilots were forced to make an emergency landing in Portland, Oregon.

In the aftermath of the incident, the to employees, Ortberg said Boeing was in a “difficult position” and that “restoring our company requires tough decisions.”

The company also delayed production of its 777X twin-engine jet and discontinued production of its 767 cargo plane, the memo noted.

Production delays with the Boeing 777X plane
Boeing is struggling with 737 MAX production.

JULIEN DE ROSA/Getty Images

The FAA announced in January that it would not grant any production expansions of Boeing’s MAX aircraft, including the 737 MAX 9, following the emergency on Alaska Airlines Flight 1282.

“The Jan. 5 Boeing 737-9 MAX incident must never happen again,” the FAA said in a press release said.

FAA Administrator Mike Whitaker said Boeing would not be cleared to expand production or add additional production lines for the 737 MAX “until we are satisfied that the quality control issues uncovered during this process are resolved,” according to the press release.

Boeing held a three-hour meeting with the FAA in June to address safety and quality concerns. Afterward, Whitaker spoke at a press conference, where he told a reporter that expanding production of 737 MAX planes was still up in the air.

The FAA told Business Insider, “This is about systemic change, and there’s a lot of work to be done. Boeing must meet milestones, and the timing of our decisions will be driven by their ability to do so.”

The agency added: “Boeing has delivered a roadmap to change its safety culture, and the FAA will make sure Boeing implements the changes they have outlined. We will not approve production increases beyond the current cap until we’re satisfied they’ve followed through on implementing corrective actions and transforming their safety culture.”

Whistleblowers report problems at Boeing
Whistleblowers have called out Boeing in 2024.

Stephen Brashear/Getty Images

Sam Salehpour, a Boeing engineer, testified at an April Senate hearing that the company ignored his reports on safety concerns, that his boss retaliated against him, and that he received threats against his physical safety.

The Senate subcommittee investigating Boeing’s safety and quality practices released a 204-page report in June. The report included accounts from several whistleblowers.

Sam Mohawk, a Boeing quality assurance inspector, said the company lost track of hundreds of bad 737 parts and instructed employees to conceal improperly stored plane parts from FAA inspectors.

Another whistleblower, Richard Cuevas, wrote in a June complaint to the FAA that holes were being incorrectly drilled on Boeing’s 787 Dreamliner planes.